Wednesday, October 20, 2010

Wednesday, October 20, 2010

Wow. We had probably the best work day ever last Saturday. We had a huge group, numbering over 35, from Cedar Grove, WI., and a smaller group of about 5 from West Bend. They got a ton of stuff done, and Tim did a great job of organizing so many different jobs and getting all of the tools ready for them. There were always at least 6 different jobs going at a time, so knowing that I'd never remember everything on my own, I took pictures of each.

Below, Marceaux is putting the finishing touches on the lift that he built for the washer and dryer that he and Jen will be using, located in their basement. He used treated lumber to build the platform that will keep the appliances off of the damp floor and any water that may end up there. Jen is excited at the prospect of not carrying her laundry up to the Hartley House every week!

They also started on the exterior of Molly's house. In the plans are a new roof and all new "siding". They started on the pump house, which was changed around last year. In the pic below, you can see a couple of ladies digging out the ground on the backside of the pump house. With the house being in the hill, there's always concern for proper water drainage. After digging out the dirt against the wall of the pump house, they put a plastic barrier against the wall to keep out ground water, then refilled the dirt with the proper pitch so the water will drain away from the building.

When comparing the pic above and below, you can see that the volunteers also firred and sheeted the exterior of the pump house, covering over where the old door had been.

They also firred and sheeted the exterior of the house that will be covered with cedar shakes. The entire exterior will basically be shakes and stone.
These guys spent the day doing masonry work. Richard mixed the mortar for them to apply the cultured stone to two of the porches on the Lumberjack Lodge (women's dorm). There's still one porch to go, then the mortar between the stones (like grout).
This gentleman worked mostly by himself in one of the unfinished bathrooms in the dorm. He drywalled the upper two feet of the room, then got a better part of the durarock (needed for tile) on the lower part of the walls.

The smaller crew from the West Bend church worked on the porch of the craft cabin (temporarily Jen and Marceaux') The did beautiful work on the tongue and groove that they put along the edge of the porch.
Looks good, huh?
Sorry, not the best picture in the world. This crew drywalled the ceilings in the dorm rooms of the Trapline Lodge (men's dorm). The Hartley House guys had already put up the plastic and much of the insulation and with the "lids" on, Tim can soon blow insulation into the ceilings, which is critical if we don't want to go broke heating this building this winter.
Below is our super speedy crew that installed the "buffalo board" (rigid sound insulation, so that future campers won't hear their neighbors snores in the night). On top of this board will be the tongue and groove. If I recall correctly, this crew got 3 1/2 rooms done.
Naturally, a fall work day is going to include raking leaves. And many a leaf did they rake! Molly and Jen headed up this crew, and I know that they were pretty pooped at the end of the day!
Raking this solid carpet of leaves made for a landscape of piles as far as the eye can see. A small crew used the tarp and pick up truck method to move the piles to the burn pile at the back of the property.
This gentleman worked with Dave Detloff, whom came up on a whim, on the tongue and groove in the room that Dave had started a couple of weeks ago. This is the last room in the Lumberjack Lodge that needed the tongue and groove. They didn't quite finish, so Dave came back yesterday and finished the job! Poly time.

A group of women started the day in the third room of the Lakeside Lodge. Karol had applied one coat of Polyurethane the previous week, so that they could start off by sanding the walls lightly, dusting off, and putting the second and final coat of polyurethane on the walls. This room will soon be used as a workout room. The circuit equipment we had donated a few years back has been in the nature center, but since that building isn't heated, it will be set up in this room. (Eventually, the equipment will be in a permanent exercise room in the new garage.)
The ladies also had to move an immense amount of tongue and groove from the dorm bathroom to the porch, then a pick up was pulled around and it was loaded into it to be moved to the other dorm where it will be used for the dorm room walls. The sand near this dorm was very soft, so both trips of wood that they loaded onto the truck weighed it down just enough that the truck, even in 4 wheel, couldn't get out without a tow from the bulldozer. It was worth it though because it was a lot of wood to move by hand.



These guys worked on trimming out the bathroom of the Birch cabin (black room in the Lumberjack Lodge)





















1 comment:

  1. That is awesome!!!

    The 4 West Bend guys were from my church. They came back SUPER excited about Camp Daniel, and 1 of them really wants to be a counselor!! It was awesome to see them so excited after one day with all of you. :D

    Thank you!

    Jojo Hensler

    ReplyDelete